Dean FPD65 Manual de instrucciones

PARTS LIST INCLUDED Frymaster, a member of the Commercial Food Equipment Service Association, recommends using CFESA Certified Technicians. 24-Hour

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-2 2.2 General Qualified, licensed, and/or authorized installation or servic

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-3 2.3 Principles of Operation The incoming gas flows through orifices and i

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-4 2.5 Pre-Installation (cont.) B. Clearances: The fryer area must be kept

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-5 2.6 Air Supply and Ventilation DANGER This appliance must be installed w

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-1 3.1 Installing the Fryer Decathlon 65 Series fryer systems are shipped in sections.

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-2 3.1 Installing the Fryer (cont.) 3. Connect red/white or red/yellow wires (Figure

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-3 3.1 Installing the Fryer (cont.) 9. Install the front connecting post on the conn

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-4 3.1 Installing the Fryer (cont.) DANGER Fryers must be at room temperature and em

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-5 3.2 Gas Connections (cont.) DANGER If gas odors are detected, the gas supply MUST

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-6 3.2 Gas Connections (cont.) C. Manual shut-off valve: This gas service supplier-i

Please read all sections of this manual and retain for future reference. NOTICE This appliance is intended for professional use only and is to be op

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-7 3.2 Gas Connections (cont.) I. Flexible Couplings, Connectors and Casters: 1.

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-8 3.3.1 Specifications 3.3.1.1 Adjustments to Different Gas Types Gas Adjustments

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-9 3.3.2 Gas Conversion Procedures (cont.) Contact factory with the following informa

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-1 4.1 Initial Start-up WARNING The on-site supervisor is responsible for ensurin

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-2 4.1.1 Pilot Lighting Procedures, Electronic Ignition Systems Initial Pilot Lig

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-3 4.2 Boil-Out Procedure DANGER Never leave the fryer unattended during the boi

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-4 4.2 Boil-Out Procedure (cont.) G. The burners will heat the boil-out solution

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-5 4.3 Final Preparation WARNING NEVER set a complete block of solid shortening

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-1 WARNING Drawings and photos used in this manual are intended to illustrate

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-2 5.2.1 Assembling the Filter (cont.) Assemble the filter as follows: 1. R

DANGER Improper installation, adjustment, maintenance or service, and unauthorized alterations or modifications can cause property damage, injury, o

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-3 5.2.1 Assembling the Filter (cont.) 4. Place the crumb tray in filter pan

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-4 5.2.2 Disassembling/Assembling and Cleaning an Optional Filter Leaf Follow

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-5 Cleaning the Filter Leaf Assembly Clean the two seal frame pieces, screens

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-6 5.3.2 Filtering Tools Assemble tools to be used for filtering. These are

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-7 5.4 Operating the Filter 5.4.1 Filter Operation CAUTION NEVER operate t

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-8 5.4.1 Filter Operation (cont.) 4. When all the oil has drained from the f

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-9 5.4.1 Filter Operation (cont.) 8. Begin the filtering process by pulling

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-10 5.4.1 Filter Operation (cont.) 11. After all shortening is pumped back i

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-11 5.4.1 Filter Operation (cont.) 14. OPTIONAL EQUIPMENT: Drain-flushes are

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 6: PREVENTATIVE MAINTENANCE 6-1 6.1 General DANGER Never attempt to clean the fryer during the cookin

FPD65 Series Gas Fryers Installation & Operation Manual TABLE OF CONTENTS Page # 1. INTRODUCTION 1-1 1.1 After Purchase 1-1 1.2

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 6: PREVENTATIVE MAINTENANCE 6-2 6.1.3 Periodic/ Annual The fryer should be inspected and adjusted peri

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 6: PREVENTATIVE MAINTENANCE 6-3 6.1.3 Periodic/ Annual (cont.) • Check filtration system integrity as

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-1 7.1 General DANGER Hot cooking oil/shortening will cause severe burns. Never a

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-2 7.2 Pilot Burner Malfunction (cont.) 3. Check all connections for cleanliness

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-3 7.3 Main Burner Malfunctions (cont.) D. Fryer will not reach the temperature

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-4 7.4 Wiring Diagram, Main HI LIMITTO J2 COMPUTER INTERFACE BOARDSPEAKERSOUNDGRD

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-5 7.5 Wiring Diagram, Filter 31C82C35C35C86C33C33C82CP2T5T4T230C27C8C9C120V12CCI

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-1 8.1 Cabinetry and Related Components 21347658910121314151617181920211122232425Typic

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-2 8.1 Cabinetry and Related Components (cont.) ITEM PART # COMPONENT 1 810-0357 C

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-3 8.2 Doors, Topcaps and Related Components 21345678910111213FPD665 Shown ITEM PAR

FPD65 Series Gas Fryers Installation & Operation Manual TABLE OF CONTENTS (CONT.) Page # 5. FILTRATION OPERATION 5-1 5.1 General

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-4 8.3 Frypots, Burners and Related Components 16201235418678159101112131421281719222

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-5 8.3 Frypots, Burners and Related Components (cont.) ITEM PART # COMPONENT 1 823-

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-6 8.4 Component Box Components 1CM4-S23456789101112131415161817 ITEM PART # COMPON

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-7 8.5 Filter Pan and Related Components 1234781011956121314 ITEM PART # COMPONENT

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-8 8.6 Oil-Drain Components 6573121517181920212223169Typical Drain Components(FPD665 S

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-9 8.6 Oil-Drain Components (cont.) ITEM PART # COMPONENT 1 823-4189 Pipe, Drain- R

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-10 8.7 Oil-Return Components Oil Disposal Plumbing(Optional)1456891011121314157232221

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-11 8.7 Oil-Return Components (cont.) ITEM PART # COMPONENT 3 813-0173 Union, ½&qu

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-12 8.8 Suction Tube, Oil-Return Components (cont.) ITEM PART # COMPONENT 1 810-0697

THIS PAGE INTENTIONALLY LEFT BLANK

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 1: INTRODUCTION 1-1 1.1 After Purchase In order to improve service, have the following chart filled in

Frymaster, 8700 Line Avenue, Shreveport, Louisiana 71106 TEL 1-318-865-1711 FAX (Parts) 1-318-688-2200 FAX (Tech Support) 1-318-219-7135 PRINTED

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 1: INTRODUCTION 1-2 1.4 Computer Information (cont.) The user is cautioned that any changes or modific

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 1: INTRODUCTION 1-3 1.6 Service Personnel 1.6.1 Definitions A. Qualified and/or Authorized Operatin

FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-1 2.1 Receiving and Unpacking Equipment A. Check that the containers are up